- Garden Sun Propane Patio Heaters
- Sun Heater Manuals
- Garden Sun Patio Heater Troubleshooting
- Garden Sun Usa Heaters
Troubleshooting
If the problem is:
And this condition exists:
Patio Heater Garden Sun model JDS04SS After lighting the jets all lightup but within minutes only half the jets stay alight. Is this dangerous? The heater is a couple of years old.Can it be repaired a. Your heater needs to be cleaned & adjusted. Contact your gas supplier for information, as to do they do the service or have someone they recommend. You will probably have to bring it in. Heater is away from windows, air intake openings, sprinklers and other water sources. Heater is at least 24 in. On top and at least 36 in. On sides from combustible materials. Page 16 CARE AND MAINTENANCE Gas odor with extreme yellow tipping of flame. Heater does NOT reach the desired temperature. Heater glow is excessively uneven.
Then do this
Pilot won’t light
Cylinder valve is closed
Open valve
Blockage in orifice or pilot tube
Clean or replace orifice or pilot tube
Air in gas line
Open gas line and bleed it (pressing control
knob in) for not more than 1 - 2 minutes or
until
you smell gas
Low gas pressure with cylinder valve
fully open
Turn cylinder valve OFF and replace
cylinder
Note:
Heater
operates
at
reduced efficiency below 40ºF
Garden Sun Propane Patio Heaters
(5ºC)
Igniter fails
Use match to light pilot; obtain new igniter
and
replace
Pilot won’t stay lit
Dirt built up around pilot
Clean dirt from around pilot
Connection between gas valve and
pilot assembly is loose
Tighten connection and perform leak check
Thermocouple is not operating
correctly
Replace thermocouple
Burner won’t light
r
e
d
n
il
y
c
e
c
a
l
p
e
r
d
n
a
F
F
O
e
v
l
a
v
r
e
d
n
il
y
c
n
r
u
T
w
o
l
s
i
e
r
u
s
s
e
r
p
s
a
G
e
g
a
k
c
o
l
b
r
a
e
l
C
e
c
i
f
i
r
o
n
i
e
g
a
k
c
o
l
B
Control knob is not in ON position
Turn control knob to ON
Burner flame is low
r
e
d
n
il
y
c
e
c
a
l
p
e
r
d
n
a
F
F
O
e
v
l
a
v
r
e
d
n
il
y
c
n
r
u
T
w
o
l
s
i
e
r
u
Sun Heater Manuals
s
s
e
r
p
s
a
G
Outdoor temperature is less than
40ºF
and tank is less than 1/4 full
Use a full cylinder
e
g
a
k
c
o
l
b
r
o
f
s
e
c
i
f
i
r
o
d
n
a
r
e
n
r
u
b
Garden Sun Patio Heater Troubleshooting
k
c
e
h
C
N
O
y
ll
u
f
b
o
n
k
l
o
r
t
n
o
C
Carbon build-up
Dirt or film on reflector and burner screen
Clean reflector and burner screen
Thick black smoke
Blockage in burner
Remove blockage and clean burner inside and
outside
8
Maintenance
WARNING
FOR YOUR SAFETY:
• Do NOT touch or move heater for at least 45 minutes
after use.
• Reflector is hot to the touch.
• Allow reflector to cool before touching.
To enjoy years of outstanding performance from your
heater, make sure you perform the following maintenance
Garden Sun Usa Heaters
activities on a regular basis:
Air flow must be unobstructed. Keep controls, burner,
and circulating air passageways clean. Signs of possible
blockage include:
a. Keeping the appliance area clear and free from combustible
materials , gasoline and other flammable vapors and liquids.
b. Not obstructing the flow of combustion and ventilation air.
Keep exterior surfaces clean.
Use warm soapy water for cleaning. Never use
flammable or corrosive cleaning agents.
While cleaning your unit, be sure to keep the area around the
burner and pilot assembly dry at all times. Do not submerge the
control valve assembly. If the gas control is submerged in water,
do NOT use it. It must be replaced.
c.Keeping the ventilation opening(s) of the cylinder enclosure
free and clear from debris.
Normal
Abnormal
1
Contents
General Safety Information.......................................
1
Contents Breakdown .............................................
Package Contents ..................................................
4
4
Assembly..................................................................
Portable Heater Location.........................................
5
7
7
7
7
8
Testing for Leakage ...............................................
7
Procedure for Leakage Test .................................
8
Turning ON the Heater ..........................................
Turning the Heater and Pilot Light OFF...................
9
Troubleshooting......................................................
Maintenance...........................................................
9
Storage...................................................................
Service....................................................................
9
Warranty.................................................................
General Safety Information
This manual contains important information about the
assembly, operation and maintenance of this patio heater.
General safety information is presented in these first few
pages and is also located throughout the manual.
Keep this manual for future reference and to educate
new users of this product. This manual should be read in
conjunction with the labeling on the product.
Safety precautions are essential when any mechanical
or
propane
fueled
equipment
is
involved.
These
precautions are necessary when using, storing, and
servicing. Using this equipment with the respect and
caution demanded will reduce the possibilities of personal
injury or property damage.
The following symbols shown below are used extensively
throughout this manual. Always heed these precautions,
as they are essential when using any mechanical or
fueled equipment.
DANGER
DANGER indicates an imminently hazardous situation
which, if not avoided, will result in death or serious injury.
WARNING
WARNING
indicates an imminently hazardous situation
which, if not avoided, could result in death or serious injury.
DANGER
WARNING
CAUTION
CAUTION
indicates an imminently hazardous situation which,
if not avoided, may result in minor or moderate personal injury,
or property damage.
WARNING:
For Outdoor Use Only
WARNING
DANGER
Failure to comply with the precautions and instructions
provided with this heater can result in death, serious bodily injury
and property loss or damage from hazards of fire,explosion,
burn, asphyxiation, and/or carbon monoxide poisoning.
Only persons who can understand and follow the instructions
should use or service this heater.
Improper installation, adjustment, alteration, service or maintenance
can cause property damage, injury or death. Read the installation,
operation and maintenance instructions thoroughly before installing
or servicing this equipment.
DANGER
CARBON MONOXIDE HAZARD
This appliance can produce carbon
monoxide which has no odor.
Using it in an enclosed space can kill you.
Never use this appliance in an enclosed
space such as a camper, tent or home.
FOR YOUR SAFETY
If you smell gas:
1. Shut off gas to the appliance.
ff
001500110003([WLQJXLVK0003DQ0003RSHQ0003ÀDPH0011
3. If odor continues, keep away from the appliance and
immediately call you gas supplier or fire department.
Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
An LP-cylinder not connected for use shall not be
stored in the vicinity of this or any other appliance.